Heating and Cooling Clinton Township

# Plumbing Service - Tanked Water Heater Responded to service call for 50-gallon power vent water heater experiencing no hot water production. Unit was a 2017 manufactured tank, approximately 7 years old, installed in 2019, and currently out of warranty. Upon arrival, confirmed no visible leaks or external damage to the unit. Performed comprehensive diagnostic evaluation of the water heater system. Inspected electrical connections at the GFCI outlet and verified proper power supply to the unit. Examined the power vent system components and verified proper operation. Checked the gas supply line connections and pressure specifications, noting the unit's 22,000 BTU input rating per manufacturer specifications. Evaluated the tank's Category III venting system for proper installation and clearances. Assessed the control board, thermostat settings, and safety mechanisms including the thermal cutoff switches. Verified compliance with flammable vapor ignition resistance requirements as indi

Completed comprehensive Gold AC inspection on 13-year-old residential HVAC system with furnace located in basement. Performed thorough evaluation of outdoor condenser unit positioned on isolation pad against exterior brick wall, inspecting cylindrical unit with vertical grille fins and top-mounted fan assembly. Verified proper operation of all electrical components including dual run capacitor assembly, contactor relay unit, and associated wiring connections with multiple colored conductors. Inspected refrigerant line set routing along exterior wall to disconnect box penetration point. All electrical terminals, spade connectors, and control circuits examined for proper connections and signs of wear. System operating within normal parameters with no immediate service needs identified. Documented equipment condition through photographic records showing capacitor assembly, contactor unit, and exterior condenser placement. Unit showing age-appropriate wear with minor dust accumulation on e

Completed full HVAC system installation including a 70,000 BTU furnace, 3-ton air conditioning unit with rear discharge configuration, and whole-home humidifier. Performed system flush, established new refrigerant lines, and reconnected existing electrical service at the breaker panel. Installed and programmed new Emerson digital thermostat for precise climate control, verified all electrical connections, and tested complete system operation to ensure proper heating and cooling functionality.

Completed comprehensive Gold AC Inspection of residential HVAC system, including evaluation of Lennox furnace unit with integrated humidifier and ductwork components. Verified thermostat operation displaying proper temperature readings at 71°F, confirmed all system controls functioning correctly, and documented equipment condition with no immediate service concerns identified.

# HVAC Maintenance Agreement Service Completed Performed scheduled commercial HVAC maintenance agreement service on Bryant Plus 90 furnace system with air handler/evaporator coil unit located on main floor. Conducted comprehensive inspection of all system components including furnace, air handler, condensate drainage system, and associated controls. Verified proper operation of equipment, documented system specifications from manufacturer labels (Model: CNPVP4821LA6AAA), and captured photographic documentation of equipment condition and warning labels for service records. System operational and in good working order upon completion of maintenance visit.

Performed preventive maintenance tune-up on a 9-year-old Lennox AC unit, model 13ACXN024-230A23. System was operational upon arrival and located in exterior side yard on concrete pad. Conducted comprehensive inspection of outdoor condensing unit, verified proper electrical connections at disconnect and meter panel, and documented equipment nameplate specifications including refrigerant charge of HFC-410A at 3 lbs 12 oz. Unit tested and confirmed in proper working condition following tune-up procedures.

Completed installation of a 3-ton rear-discharge air conditioning system with matching evaporator coil, connecting to existing Carrier furnace in basement mechanical room. Mechanical permit was requested and all work performed to code specifications, with system reconnected and operational upon completion.

Completed full system replacement estimate for 16-year-old HVAC equipment with air handler/coil located in first floor closet. Documented existing system conditions including severely corroded refrigerant lines on exterior with significant rust deterioration, multiple utility penetrations through building envelope with accumulated debris at foundation level, and electrical service routing along exterior wall. Advised property owner that condenser area must be cleared of debris and animal waste prior to installation, and confirmed inspection scheduling is weather-dependent with minimum 65-degree temperature requirement for accurate equipment evaluation.

Completed Gold AC Inspection on 16-year-old Lennox air conditioning system with outdoor condenser unit and first floor closet air handler. Performed comprehensive system evaluation including visual inspection of condenser unit, which showed dirt accumulation on top panel and surrounding area requiring debris clearance. Evaporator coil inspection revealed heavy soiling with significant dust, dirt, and debris buildup throughout finned surfaces, along with cobweb accumulation affecting airflow efficiency. Documented equipment condition through photographic evidence showing condenser unit positioning on grade with proper clearances and electrical disconnect box mounting. Advised customer on necessary maintenance recommendations including condenser area clearance from debris and animal waste, and noted evaporator coil cleaning requirements to restore optimal system performance and efficiency.

Completed Gold AC Inspection on a 2-year-old residential air conditioning system with air handler located in basement and condenser unit positioned on exterior gravel pad. Performed comprehensive system evaluation including visual inspection of outdoor condenser unit, which showed clean exterior surfaces, properly secured fan assembly, and no visible signs of damage, rust, or deterioration. Advised homeowner that air filter replacement is required for optimal system performance.

Completed Gold Furnace Inspection on a 9-10 year old HVAC system. Performed comprehensive combustion analysis using Testo 310 analyzer, which confirmed proper operation with readings of 115°F and 5 ppm carbon monoxide levels, indicating safe and efficient combustion. Inspected associated water heater manufactured by Bradford White Corporation, verified all safety labels and warning placards were intact and legible, and confirmed proper copper piping connections were secure with no visible leaks or corrosion.

Completed full HVAC system installation including a 90,000 BTU high-efficiency furnace and 3-ton air conditioning unit configured for left-side placement. Installed all ductwork connections, gas valve assembly, electrical wiring, and refrigerant lines, then reconnected existing utility connections and verified proper operation of all components. Mechanical permit was requested and utility rebate documentation was processed for the customer.

Completed comprehensive Gold AC inspection on 16-year-old residential cooling system with basement-located air handler and outdoor condensing unit. Performed full system evaluation including inspection of indoor evaporator coil assembly, Enviracare Elite humidifier integration with ductwork, and outdoor condenser unit positioned on concrete pad against brick exterior. Verified proper operation of all components, checked electrical connections at disconnect box and outdoor receptacle, confirmed adequate clearance around condenser unit, and assessed overall system condition. Unit currently operating as designed with all safety controls functioning properly.

Completed comprehensive tune-up service on a 10-year-old residential air conditioning system with basement coil and outdoor condenser unit. Performed full system inspection including condenser coil cleaning, verified proper refrigerant levels, checked electrical connections, tested capacitor and contactor operation, and confirmed fan motor functionality. Unit operating within manufacturer specifications with no immediate service needs identified; condenser fins in good condition with minimal debris accumulation noted around exterior placement area.

Disconnected and temporarily relocated 10-year-old air conditioning condenser unit from exterior patio location to interior dining room to accommodate customer's patio renovation project. Unit was safely dismounted from exterior wall bracket, refrigerant lines were properly capped and secured, and condenser was positioned indoors per homeowner specifications until patio reconstruction is complete.

Completed Gold AC inspection on 10-year-old system with air handler located in basement. Unit is operational and functioning properly. Advised customer that area surrounding outdoor condenser unit needs to be cleared of debris and animal waste to ensure proper airflow and system efficiency.

Completed comprehensive Gold AC inspection on 3-year-old Daikin split system with air handler located in hallway. Performed full system evaluation of outdoor condensing unit, verified proper operation of all components, checked refrigerant levels and pressures using manifold gauges, and inspected electrical connections at disconnect box. Unit operating within normal parameters with no deficiencies noted.

Provided estimate for replacement of aging outdoor AC condenser unit located on exterior concrete pad alongside building. Existing unit is operational but over 10 years old, with associated basement furnace equipment running on natural gas. Documented current system configuration including refrigerant lines, electrical disconnect, and utility connections for replacement specifications.

Completed comprehensive Gold AC Inspection and spring maintenance on a 2-year-old air conditioning system. Performed full system evaluation including inspection of outdoor disconnect switch, verified proper electrical connections and amperage ratings at 30 AMP/240 VAC service disconnect. Assessed integrated humidifier unit connected to ductwork system, confirmed proper installation and operational status. All components found to be in good working condition with no immediate repairs required.

Completed comprehensive Gold AC inspection on residential cooling system. Unit confirmed operational at time of service. Performed thorough evaluation of outdoor condenser unit, including visual inspection of fan assembly, housing condition, and proper placement on concrete pad. Inspected electrical disconnect box mounted on exterior wall, verified accessibility and condition of disconnect mechanism and fuse holder. Air handler and evaporator coil located in basement area. Documented equipment condition through photographic records showing exterior disconnect components with visible specification plate and outdoor condenser unit positioned in backyard setting. Provided estimate for thermostat replacement as requested. System operating normally with no immediate service concerns identified during inspection.